1. Check whether the concrete mixer of Zhongke is smooth and whether the four legs are firmly supported;

　　2. 机器空载运行是否正常;

　　2. Whether the machine operates normally without load;

　　3.将泵注满水并测试一次;

　　3. Fill the pump with water and test once;

　　4. 检查电器接地情况。

　　4. Check the electrical grounding.

　　二是自上料水泥搅拌车的使用要求

　　Second, the use requirements of concrete mixer

　　1.每次添加的搅拌料不得超过规定的值，料斗只有在搅拌出后才能提起进料;

　　1. The mixing material added each time shall not exceed the specified value, and the hopper can only lift the feed after mixing out;

　　2.搅拌缸反转时，切勿拉操作手柄;

　　2. When the mixing cylinder is reversed, do not pull the operating handle;

　　3.为减少粘罐现象，进料斗的顺序为石头-水泥-沙子或沙子-水泥-石头;

　　3. In order to reduce tank sticking, the order of feeding hopper is stone cement sand or sand cement stone;

　　4.搅拌桶进料时及时加水，缩短搅拌时间，减少粉尘飞扬;

　　4. Add water in time when feeding the mixing barrel to shorten the mixing time and reduce dust flying;

　　5.料斗抬起后，任何人不得停留或从料斗下通过;当必须在料斗下进行维修时，应先用安全链将料斗紧固，才能进行维修。

　　5. After the hopper is lifted, no one is allowed to stay or pass under the hopper; when maintenance must be carried out under the hopper, the hopper shall be fastened with safety chain before maintenance.

　　6.严禁非工作人员随意拉动控制手柄;机器不运转时，必须用安全钩固定;

　　6. It is strictly prohibited for non staff to pull the control handle at will; when the machine is not running, it must be fixed with a safety hook;

　　7、注意电气安全，经常检查地面是否良好，防止电机受潮，防止损坏电气元件、电线;

　　7. Pay attention to electrical safety, check whether the ground is in good condition, prevent the motor from getting damp, and prevent damage to electrical components and wires;

　　8.当断电时，可以用曲柄摇动减速带盘，将物料从气缸中取出;

　　8. When the power is cut off, the crank can be used to shake the reduction belt plate to take out the material from the cylinder;

　　9.当机器停放时，必须放下四个支撑脚来支撑机器的重量;

　　9. When the machine is parked, four supporting feet must be put down to support the weight of the machine;

　　3自上料水泥搅拌车的完成要求

　　3 requirements for completion of concrete mixer

　　1.停机前，应加入一定量的石子和水，搅拌5-10分钟后释放，以消除缸内堆积，避免粘罐;

　　1. Before shutdown, a certain amount of stones and water shall be added and released after mixing for 5-10 minutes to eliminate accumulation in the cylinder and avoid tank sticking;

　　2. 清洁有灰堆积和粘着的混凝土;

　　2. Clean the concrete with ash accumulation and adhesion;

　　3.将料斗置于输送位置，悬挂安全链;所述控制手柄由安全钩固定;

　　3. Place the hopper in the conveying position and hang the safety chain; the control handle is fixed by the safety hook;

　　4. 切断电源，锁好电箱;

　　4. Cut off the power supply and lock the electric box;

　　5. 在严寒季节，将供水系统的水全部排干;

　　5. In the severe cold season, drain all the water in the water supply system;

　　6. 向每个润滑点添加必要的润滑油。

　　6. Add necessary lubricating oil to each lubricating point.

　　以上是水泥自动搅拌车厂家小编为大家介绍的相关内容，想要了解更多内容，欢迎访问网站：http://www.sdzkjf.cn

　　The above is the relevant content introduced to you by China Science and technology concrete mixer manufacturer. To learn more, please visit the website: http://www.sdzkjf.cn