水泥自动搅拌车是一种具备危险性质的设备，所以使用的时候要万分注意，尤其是从出车到卸料的过程要操作正确，不然非常容易出现问题，那么下面讲讲注意事项吧。认真检查，及时发现并排除故障。

　　Cement automatic mixer is a kind of dangerous equipment, so pay attention to the use of time, especially from the car to the unloading process to operate correctly, otherwise it is very prone to problems, then the following points for attention. Careful inspection, timely discovery and troubleshooting.

　　开车前注意检查。点火前检查发动机机油、防冻液、润滑油和冷却水，不足时重新添加。水泥自动搅拌车启动后，检查轮胎气压和轮胎是否漏气。检查车灯，尤其是腰灯，确保它们照在轮胎边缘。用抹布清洁后视镜和两侧车窗。施工现场路况复杂，光线不好先保证视线！

　　Check before driving. Check engine oil, antifreeze, lubricating oil and cooling water before ignition, and re-add if insufficient. After the cement mixer starts, check the tire pressure and tire leakage. Check your headlights, especially your waist lights, to make sure they shine on the edge of your tires. Clean the mirrors and side Windows with a rag. Construction site road conditions are complex, the light is not good to ensure sight first!

　　确保水箱中有足够的水，并且有减水剂。由于各种原因，当物料太干，无水不能排放时，减水剂是救命稻草，否则锅子会闷等一万大洋。确认搅拌罐已停止。发动机起动时，如果罐处于高速旋转状态，瞬时力会很大，减速器会损坏。

　　Make sure there is enough water in the tank and there is water reducing agent. For a variety of reasons, when the material is too dry to discharge without water, high-efficiency water reducer is a lifesaver, otherwise the pot will be boring waiting for ten thousand dollars. Make sure the mixing tank is stopped. When the engine starts, if the tank is in a state of high speed rotation, the instantaneous force will be large and the reducer will be damaged.

　　装载时记得清洁。特别是车辆露天停放、下雨时，应将罐内积水、可能的树叶等杂物排干，以免影响混凝土质量。清洗完毕后，关闭水箱进气口，打开水箱出风口将气体排出，因为在压力作用下，水管连接不好，容易渗漏，影响其他车辆的。再次检查轮胎的石块和铁钉，因为停车时无法检测到轮胎与地面的接触。

　　Remember to clean when loading. Especially when the vehicle is parked in the open air and it rains, the tank should be drained of water, possible leaves and other sundries, so as not to affect the quality of concrete. After cleaning, close the inlet of the water tank and open the outlet of the water tank to discharge the gas, because under the action of pressure, the water pipe is not connected well, easy leakage, affecting the safety of other vehicles. Check again for stones and nails as contact with the ground cannot be detected during parking.

　　开车要慢。搅拌车高，易于翻车！转弯前提前减速降档，转弯时尽量不要踩刹车。始终通过后视镜观察罐是否转动，并尝试减慢速度。如果车速太高，车辆很容易摆动。在长时间行驶或下坡前，您应该习惯于测试制动器。对于重型车辆，不要挂空档滑下山。下坡时，提前减速，然后减速，然后再减速。挂档制动效果更好。

　　Drive slowly. Agitator high center of gravity, easy to overturn! Slow down and downshift before turning, and try not to brake when turning. Always look through the rearview mirror to see if the tank is rotating and try to slow it down. If the speed is too high, the vehicle will wobble easily. You should get used to testing the brakes before a long ride or downhill. For heavy vehicles, do not slide downhill in neutral. When going downhill, slow down early, then slow down, then slow down again. Gear braking works best.

　　倒车时一定要减速。不要总是把头伸出窗外，要看两边的后视镜。如果你不确定，停下来看清楚，然后翻过来。很多路都是挖掘机铺的，所以车子很容易下沉。

　　Be sure to slow down when backing up. Don't always stick your head out of the window. Look in both mirrors. If you're not sure, stop and look, then flip over. Many roads are paved by excavators, so the car is easy to sink.

　　卸料前弄湿料斗溜槽。卸料时，应尽量将水泥自动搅拌车停放在平地上，卸料前应将卸料斗的溜槽打湿，以便于清洗。卸料时不要大意，要与卸料者保持良好关系。卸料时自己看着，以免卸料工人乱操作卸料杆。每次罐处于正反转中间位置时更好停车，以保护减速器、托轮等。仔细清洗混合罐。

　　Wet hopper chute before unloading. When unloading, cement automatic mixing truck should be parked as far as possible on the level, before unloading should be wet discharge hopper chute, in order to facilitate cleaning. Don't be careless when unloading, keep a good relationship with the unloading person. Watch yourself when unloading, so as to avoid unloader to operate the unloading rod. It is best to stop every time the tank is in the middle position of positive and negative rotation to protect the reducer, supporting wheels, etc. Clean the mixing tank carefully.

　　水泥自动搅拌车从出车到卸料要注意什么？总之，这个过程中要注意的事项太多了，但所做的事项完全是为了保证自己的以及保障工作的完成，是值得的！更多内容就来网站www.sdzkjf.cn咨询吧！

　　Cement automatic mixer from the car to discharge what to pay attention to? All in all, there are too many things to pay attention to in this process, but it is worth doing to ensure their safety and guarantee the completion of the work! More content to the website www.sdzkjf.cn consultation!