The function of the driving device is to drive the concrete storage tank to rotate. It consists of a power take-off, a universal shaft, a hydraulic pump, a hydraulic motor, a control valve, a hydraulic oil tank and a cooling device.

如果这部分因故障停止工作，混凝土贮罐将不能转动，这会导致车内混凝土报废，严重的甚使整罐混凝土凝结在罐内，造成混凝土搅拌运输车报废。

If this part stops working due to failure, the concrete storage tank will not rotate, which will lead to the scrap of concrete in the vehicle, and even the whole tank of concrete will condense in the tank, resulting in the scrap of concrete mixer truck.

因此，驱动装置是否可靠是使用中必须高度重视的问题。为保证驱动装置完好可靠，应做好以下维护工作：

Therefore, whether the driving device is reliable or not is a problem that must be paid great attention to in use. In order to ensure that the driving device is intact and reliable, the following maintenance work shall be done:

a．万向转动部分是故障多发部位，应按时加注润滑脂，并经常检查磨损情况，及时修理更换。车队应有备用的万向轴总成，以保证一旦发生故障能在几十分钟内恢复工作。

a. The universal rotating part is the fault prone part. It should be filled with grease on time, checked for wear frequently, and repaired and replaced in time. The fleet shall have spare cardan shaft assembly to ensure that it can resume operation within several minutes in case of failure.

b．保证液压油清洁。混凝土搅拌运输车工作环境恶劣，一定要防止污水泥沙进入液压系统。液压油要按使用手册要求定期更换。一旦检查时发现液压油中混入水或泥沙，就要立即停机清洗液压系统、更换液压油。

b. Ensure that the hydraulic oil is clean. The working environment of the concrete mixer truck is bad, so it is necessary to prevent the dirty cement sand from entering the hydraulic system. The hydraulic oil shall be replaced regularly according to the requirements of the user manual. Once it is found that water or sediment is mixed in the hydraulic oil during inspection, it is necessary to shut down the machine immediately to clean the hydraulic system and replace the hydraulic oil.

c．保证液压油冷却装置有效。要定时清理液压油散热器，避免散热器被水泥堵塞，检查散热器电动风扇运转是否正常，防止液压油温度超标。液压部分只要保证液压油清洁，一般故障不多；但生产厂家不同，使用寿命则不一样。

c. Ensure that the hydraulic oil cooling device is effective. Clean the hydraulic oil radiator regularly to avoid the radiator being blocked by cement, check whether the electric fan of the radiator operates normally, and prevent the hydraulic oil temperature from exceeding the standard. As long as the hydraulic oil is kept clean, there are not many faults in the hydraulic part, but the service life is different with different manufacturers.

有了自上料水泥搅拌车上面的小总结，希望对广大客户有所帮助，如果有什么不理解的或者寻求帮助的请点击我们的网站：http://www.sdzkjf.cn或者来电咨询，我们会尽全力为您

With the summary from the charging mixer, we hope to help our customers. If you don't understand or ask for help, please click our website: http://www.sdzkjf.cn or call us for consultation. We will try our best to solve it for you