1、检查、发现问题并排除故障

1. Check, identify problems, and troubleshoot

水泥自上料搅拌车怕跑在路上，罐子不转了，一般来说装满混凝土的罐子一般停管不能超过2小时，C40级以上的混凝土罐子就一直不能停。

The cement self loading mixer truck is afraid of running on the road and the tank won't rotate. Generally speaking, the tank filled with concrete can't be stopped for more than 2 hours, and the concrete tank of grade C40 or above cannot be stopped for a long time.

卡车启动后，让搅拌罐低速转动，检查胎压，看是否有漏气的轮胎，检查轮胎内是否有石块、钉子等东西卡在里面，并及时清理干净。

After the truck starts, let the mixing tank rotate at low speed, check the tire pressure, see if there are any leaking tires, check if there are stones, nails, and other things stuck inside the tires, and clean them in a timely manner.

检查侧灯，确保照在轮胎边缘，因为施工现场经常会有钢筋等杂物随意堆积，胎侧薄弱。

Check the side lights to ensure they are on the edge of the tires, as there are often loose piles of steel bars and other debris on the construction site, resulting in weak tire sides.

2、确保水箱中有足够的水和减水剂

2. Ensure that there is sufficient water and water reducing agent in the water tank

由于各种原因，当材料过于干燥，不加水无法排出时，减水剂是一种救命稻草，可以保证混凝土的流动性。

Due to various reasons, when the material is too dry and cannot be discharged without adding water, water reducing agents are a life-saving straw that can ensure the fluidity of concrete.

3、确认搅拌罐处于停止状态

3. Confirm that the mixing tank is in a stopped state

因为水泥自上料搅拌车发动机启动时，万一搅拌罐高速旋转，瞬时受力会很大，会对减速器和泵电机系统造成伤害。

Because when the engine of the cement self feeding mixer truck starts, if the mixing tank rotates at high speed, the instantaneous force will be very large, which will cause damage to the reducer and pump motor system.

操作：

Safe operation:

1.锁定驾驶室内防逆转手柄，以防载物排在道上。

1. Lock the anti reverse handle inside the driver's cab to prevent loads from lining up on the road.

2.将定位手柄卡入定位卡盘内，锁止机构卡住伸缩总成，固定滑料槽。

2. Insert the positioning handle into the positioning chuck, lock the telescopic assembly with the locking mechanism, and fix the sliding groove.

3.车尾操作手柄应置于“搅动”档内；油门置于怠速位置。

3. The rear operating handle should be placed in the "stirring" position; Place the throttle in the idle position.

4.车辆在行驶过程中，关闭为水箱供气的气源阀门，以免影响车辆的制动性。

4. During driving, close the air supply valve for the water tank to avoid affecting the braking performance of the vehicle.

5.运行时，加长滑料槽必须翻转卸下，放置在挡泥板的专用位置并锁定。以防摆动伤人或影响其它车辆的运行。

5. During operation, the extended sliding chute must be overturned and removed, placed in a dedicated position on the mudguard and locked. To prevent swinging from injuring people or affecting the operation of other vehicles.

6.水泥自上料搅拌车穿越桥、洞、库等设施时，必须要注意通过高度的尺寸，以免发生碰撞造成伤害。

When the cement self loading mixer truck passes through facilities such as bridges, tunnels, and warehouses, attention must be paid to the size of the passing height to avoid collision and injury.

水泥自上料搅拌车开工干活的必要事项相关内容就讲解导致这里了，您对此有怎疑惑或者需求来我们网站http://www.sdzkjf.cn了解！

The necessary matters for starting the work of the cement self loading mixer truck have been explained here. Do you have any doubts or needs to come to our website http://www.sdzkjf.cn Understand!