自上料水泥搅拌车的刹车关重要，以下是几点需要注意的事项：

The braking safety of the self loading cement mixer truck is crucial, and the following are some points to be noted:

1.检查制动系统：在每次启动车辆前，一定要检查制动系统是否正常。包括刹车片和刹车鼓的磨损程度，制动液的水平等。

1. Check the braking system: Before starting the vehicle every time, be sure to check whether the braking system is normal. Including the wear degree of brake pads and brake drums, and the level of brake fluid.

2.避免急刹车：自上料水泥搅拌车的车身比较高，急刹车会导致车身前倾，容易导致侧翻。因此，驾驶员需要避免急刹车，尽量保持平稳的行驶状态。

2. Avoid sudden braking: The body of the self loading cement mixer truck is relatively high, and sudden braking can cause the body to lean forward and easily cause rollover. Therefore, drivers need to avoid sudden braking and try to maintain a smooth driving state.

3.注意距离：自上料水泥搅拌车因为体积比较大，行驶时需要注意与其他车辆和行人的距离，以免发生碰撞事故。

3. Attention to distance: Due to the large volume of the self loading cement mixer truck, it is necessary to pay attention to the safe distance from other vehicles and pedestrians when driving to avoid collision accidents.

4.注意制动时间：在行驶过程中，驾驶员需要留意制动时间，避免持续制动时间过长，以免制动器过热而导致刹车失灵。

4. Pay attention to braking time: During driving, the driver needs to pay attention to the braking time to avoid prolonged braking, so as to avoid overheating the brake and causing brake failure.

5.保持刹车干燥：雨天行驶时，需要注意制动器的干燥状况，避免制动器潮湿而导致刹车失灵。

5. Keep the brake dry: When driving in rainy days, it is necessary to pay attention to the dry condition of the brake to avoid brake failure caused by the wet brake.

此外自上料水泥搅拌车踩刹车时发抖这种情况大多出现在老车身上，因为使用磨损，混凝土搅拌车刹车盘片表面平整度已经有失准了。所以建议是视情况选择采用车床光盘工艺打磨，又或者更换刹车片(对于车龄较大的混凝土搅拌车)。

In addition, the shaking of the self loading cement mixer truck when stepping on the brake mostly occurs on the old car body. Due to wear and tear, the surface flatness of the brake disc of the concrete mixer truck has been inaccurate. Therefore, it is recommended to use a lathe disc process for polishing, or to replace the brake pads (for older concrete mixer trucks), depending on the situation.

自上料水泥搅拌车刹车快停住的时候方向盘总会向一侧偏转，这种情况其实就是我们俗称的“偏刹”，故障原因主要是自上料水泥搅拌车刹车系统左右分泵对刹车片作用力不均匀导致的。

When the brake of the self loading cement mixer truck is about to stop, the steering wheel will always deflect to one side. This situation is actually known as "biased braking". The main cause of the failure is the uneven force exerted on the brake pads by the left and right wheel cylinders of the self loading cement mixer truck brake system.

而在行驶过程中由于自上料水泥搅拌车刹车盘转动速度快，分泵作用不均匀在快速摩擦时的差别是很小的，我们也很难感觉到。

During driving, due to the fast rotation speed of the brake disc of the self loading cement mixer truck, the uneven action of the slave pump during rapid friction has a small difference, which is difficult to feel.

开动小型搅拌车前需要热车十多分钟才有刹车力，自上料水泥搅拌车刹车系统是由发动机提供压力推动卡钳夹住刹车盘(盘刹)，或者是推动刹车盘与刹车鼓发生摩擦(鼓刹)。

Before starting a small mixer truck, it takes more than ten minutes to warm up the truck to have braking force. The brake system of the self loading cement mixer truck uses the engine to provide pressure to push the caliper to clamp the brake disc (disc brake), or to push the brake disc to rub against the brake drum (drum brake).

所以像上述的状况，可能是提供压力的传输管道出现失压，导致无法及时提供刹车力。这种情况应检查刹车总泵的真空助力皮管和自上料水泥搅拌车发动机的借口处是否有龟裂或松脱的状况。

Therefore, in situations like the above, there may be a loss of pressure in the transmission pipeline that provides pressure, resulting in the inability to provide braking force in a timely manner. In this case, check the vacuum booster hose of the brake master cylinder and the engine of the self loading cement mixer truck for cracks or looseness.

总之，自上料水泥搅拌车的刹车需要驾驶员时刻保持警觉，检查制动系统的正常性，注意行车距离和制动时间，及时维护保养制动器，确保自上料水泥搅拌车在行驶过程中的。您有怎样的疑惑或者需求就来我们网站http://www.sdzkjf.cn留言咨询吧！

In short, the braking safety of the self loading cement mixer requires the driver to remain vigilant at all times, check the normality of the braking system, pay attention to the driving distance and braking time, and maintain the brakes in a timely manner to ensure the safety of the self loading cement mixer during driving. If you have any doubts or needs, please come to our website http://www.sdzkjf.cn Leave a message for consultation!