1、 Check whether the hydraulic oil leaks completely (change the pipe if the pipe is broken, change the seal if the seal is broken)!

二、检查一下散热器风扇在转没有，液压油乳化变白没有，液压油温度超过90度，液压系统就没有压力，罐子就不转了!(这种情况不要着急，用水冷却一下液压泵，液压马达，液压油温度下来，罐子就可以转动了。把料放出来，赶紧修理散热器或更换液压油!)

2、 Check whether the radiator fan is running, whether the hydraulic oil emulsion turns white, if the hydraulic oil temperature exceeds 90 degrees, the hydraulic system will have no pressure, and the tank will not rotate! (in this case, do not worry, cool the hydraulic pump and hydraulic motor with water, and the tank will be able to rotate when the hydraulic oil temperature drops. Put the material out and repair the radiator or change the hydraulic oil quickly!)

三、运输途中没有注意，罐子停了!混凝土塌住了，罐子翻不过去!(感觉有压力能转一点就可能是这种情况)

3、 Didn't pay attention to the transportation, the tank stopped! The concrete collapsed, and the tank couldn't turn over! (this may be the case if you feel pressure and can turn a little.)

四、发动机故障(不可能哦，轰隆隆响起在!!)

4、 Engine failure (impossible, boom in the ring!)

五、传动轴十字节损坏，断了(a断了立即更换一根传动轴;b传动轴好的);

5、 The cross section of transmission shaft is damaged and broken (a is broken, replace a transmission shaft immediately; B drive shaft is good);

六、液压泵损坏了(情况复杂一点，内泻严重，其他损坏);

6、 The hydraulic pump is damaged (the situation is more complicated, the internal leakage is serious, and other damages);

以上六种情况出现，且混凝土没有凝结，液压马达、减速机没有故障，可以使用应急装置，用另一辆搅拌车的液压泵带动液压马达转动罐子，将混凝土放出，再检修!

If the above six cases occur, and the concrete does not condense, and the hydraulic motor and reducer have no fault, you can use the emergency device, use the hydraulic pump of another mixer to drive the hydraulic motor to rotate the tank, release the concrete, and then overhaul!

七、液压马达损坏了!

7、 The hydraulic motor is damaged!

八、减速机坏了!!

8、 The reducer is broken!!

七、八两种情况出现，不能使用应急装置!可以将罐体上的检查盖打开将混凝土放出。

7、 In case of two situations, the emergency device can not be used! The inspection cover on the tank can be opened to release the concrete.

⊙可以用塔机、卷扬机将罐体检查盖旋转到下方，将混凝土放出;

⊙ tower crane and winch can be used to rotate the tank inspection cover to the lower part to release the concrete;

⊙罐子卡住了旋转不动怎么办?

⊙ what to do if the jar is stuck and can't rotate?

⊙可以在罐体侧下方用气割开一个50厘米见方的孔(注意避开罐里的螺旋叶片，割下的罐壁一定保留，修复起来迅速、方便而且美观)，将混凝土放出。

⊙ a 50cm square hole can be cut under the side of the tank with gas (pay attention to avoid the spiral blade in the tank, keep the cut tank wall, and repair it quickly, conveniently and aesthetically), and discharge the concrete.

本文由水泥自上料搅拌车提供技术支持，更多的详细精彩内容请点击http://www.sdzkjf.cn我们的网站，我们将会全心全意为您提供满意的服务

This paper is supported by Zhongke self feeding mixer. For more details, please click http://www.sdzkjf.cn Our website, we will wholeheartedly provide you with satisfactory service