水泥自上料搅拌车现在无论是在工地建筑还是道路维修都有广泛的应用，那么你知道搅拌车的空调滤清器使用要注意什么事项吗？下面小编来为您讲解一番。
Cement self loading mixer trucks are now widely used both in construction sites and road maintenance. Do you know what precautions should be taken when using air conditioning filters on mixer trucks? The editor will explain it to you.
夏天和冬天都会使用到空调，一般在这两个季节到来之前，就需要对空调进行清理、清洁。空调滤清器在使用过程中应定期清洁或更换，不然堵塞的滤清器会阻止并减少空气进入蒸发箱。
Air conditioners are used in both summer and winter, and generally need to be cleaned before these two seasons arrive. Air conditioning filters should be regularly cleaned or replaced during use, otherwise clogged filters will prevent and reduce air from entering the evaporation tank.
因为水泥自上料搅拌车在使用中，若空气滤清器过脏，会使进入汽缸内的空气量减少，造成搅拌车的动力性能下降，速度加不上去。另外，空气滤清器的质量应当可靠，若过滤不清，细微灰尘进入汽缸，将使活塞与缸筒之间的磨损加剧，从而降低发动机整体的使用寿命，这点是十分重要的。
If the air filter of the cement self loading mixer truck is too dirty during use, the amount of air entering the cylinder will be reduced, resulting in a decrease in the dynamic performance of the mixer truck and inability to increase its speed. In addition, the quality of the air filter should be reliable. If the filter is not clear and fine dust enters the cylinder, it will aggravate the wear between the piston and the cylinder barrel, thereby reducing the overall service life of the engine. This is very important.
空调虽然开的很大，但依然感觉不凉，有的车辆车内还伴有异味，对于没有空调滤清器的空调车辆，当感觉出风口风量减少或开空调后车内有异味时，请到修理厂清洗蒸发箱，清洁后，会感觉车内空气新鲜，凉度增加，相对也提高了搅拌车驾驶的舒适性。搅拌车的空气滤清器一般需要在1.5万公里更换一次，5000公里清洁一次。
Although the air conditioner is heavily turned on, it still feels not cool. Some vehicles also have a peculiar smell inside. For air-conditioned vehicles without air conditioning filters, when you feel that the air volume at the air outlet decreases or there is a peculiar smell inside the vehicle after the air conditioner is turned on, please go to the repair shop to clean the evaporation tank. After cleaning, you will feel that the air in the vehicle is fresh and the cooling degree increases, which relatively improves the driving comfort of the mixer truck. The air filter of a mixing truck generally needs to be replaced every 15000 kilometers and cleaned every 5000 kilometers.
合格的空气滤清器可以长时间使用而无需保养。吸入空气在与燃油混合之前，要先经过空气滤清器，滤去灰尘、碳、部分水蒸气及其他杂物后再进入气缸。从理论上讲，一单位体积的燃油燃烧时，大约需要一万单位体积的清洁空气。空气滤清器的正常维护的更换周期为4.8万千米，每2.4万千米进行一次常规检查。
Qualified air filters can be used for a long time without maintenance. Before mixing the inhaled air with fuel, it must first pass through the air filter to remove dust, carbon, some water vapor, and other debris before entering the cylinder. In theory, when a unit volume of fuel is burned, about 10000 units of clean air are required. The normal maintenance and replacement cycle of the air filter is 48000 kilometers, and a routine inspection is conducted every 24000 kilometers.
大气中常见的三种杂质有灰尘、残渣和碳粒。工地、风沙地区灰尘浓度较高，空气滤清器的更换频率要高一些；高速公路和车辆密集区域，车辆排放物多，空气中碳含量较高。在检查空气滤清器的时候，要仔细查看褶皱内部深处。有时候外面看似干净，内部已经非常脏了，这种情况下空气滤清器的过滤能力减弱，建议及时更换。
The three common impurities in the atmosphere are dust, residue, and carbon particles. The dust concentration in construction sites and windy sand areas is high, and the replacement frequency of air filters should be higher; Highways and densely populated areas have high vehicle emissions and high carbon content in the air. When inspecting the air filter, carefully examine the depth of the wrinkles inside. Sometimes the outside looks clean, but the inside is already very dirty. In this case, the filtering ability of the air filter decreases. It is recommended to replace it in a timely manner.
That's all about the precautions for using the air conditioning filter on the mixer truck. If you have any doubts or use needs about this, please come to our website http://www.sdzkjf.cn Leave a message for consultation!
上一篇：自上料水泥搅拌车气刹和油刹的不同之处
下一篇：降低自动搅拌车的故障率要注意什么？
