都知道水泥自动搅拌车是运输混凝土的专用车辆，我们先看看水泥自动搅拌车的主要使用特点，掌握以下几点。

We all know that cement automatic mixer is a special vehicle for transporting concrete. Let's first look at the main features of cement automatic mixer and master the following points.

1、搅拌车液压传动系统液压油的压力、油量、油质、油温应达到规定要求，无渗漏现象

1. The hydraulic oil pressure, oil quantity, oil quality and oil temperature of the hydraulic transmission system of the mixing truck shall meet the specified requirements without leakage

2、搅拌运输中，装载混凝土量不能超过允许装载质量。

2. During mixing and transportation, the amount of concrete loaded shall not exceed the allowable loading mass.

3、搅拌车在露天停放时，装料前应先将搅拌筒反转，使筒内的积水和杂物排出。装料前，好先向筒内加水，使进料流畅，防止粘料。

3. When the mixing truck is parked in the open air, the mixing drum shall be reversed before loading to discharge the accumulated water and sundries in the drum. Before loading, add water into the cylinder to make the feeding smooth and prevent sticking.

4、搅拌车行驶中，接长的卸料槽必须翻转后固定在卸槽上，再转至与车身垂直部位，用销轴与机架固定，防止由于不固定而引起摆动，打伤行人或影响车辆运行。

4. During the driving of the mixer truck, the extended discharge chute must be turned over and fixed on the discharge chute, then turned to the vertical position with the body, and fixed with the pin shaft and the frame to prevent the swing caused by unfixed, hurting pedestrians or affecting the vehicle operation.

5、搅拌车通过桥、洞、库等设施时，应注意通过高度及宽度，以免发生碰撞事故。特别需要注意的是现在四轴罐车的长度很长，在通过桥洞高度接近极，长长的车身是下圆弧路面的一道弦，能通过的高度会降低。

5. When the mixing truck passes through the bridge, tunnel, warehouse and other facilities, pay attention to the height and width to avoid collision accidents. It is particularly important to note that the length of the four-axle tank car is very long now. When the height of passing through the bridge is close to the limit, the long body is a chord of the lower arc road, and the height of passing through will be reduced.

6、搅拌装置连续运转时间不超过8h。

6. The continuous operation time of the mixing device shall not exceed 8h.

7、搅拌车运送混凝土的时间不得超过搅拌车规定的时间，以免影响混凝土质量。

7. The mixing truck shall not transport concrete more than the time specified by the mixing truck to avoid affecting the concrete quality.

8、运送混凝土途中，搅拌筒不得停转，以防混凝土产生初凝及离析现象。

8. During the transportation of concrete, the mixing drum shall not be stopped to prevent the initial setting and segregation of concrete.

9、搅拌筒由正转变为反转时，必须先将操纵手柄放置中间位置，待搅拌筒停转后，再将操纵手柄放置反转位置。

9. When the mixing drum changes from positive to reverse, the operating handle must be placed in the middle position first, and then placed in the reverse position after the mixing drum stops rotating.

10、水箱的水量要尽量保持装满，以防急用。冬季停车时，要将水箱和供水系统的水放净。

10. The water tank should be kept as full as possible in case of emergency. When parking in winter, drain the water in the water tank and water supply system.

混凝土运输中通过搅拌筒的缓慢旋转，可有效地防止防止混凝土初凝及离析，因而能保证混凝土的输送质量。更多相关内容就来我们网站http://www.sdzkjf.cn咨询吧！

The slow rotation of the mixing drum during concrete transportation can effectively prevent the initial setting and segregation of concrete, thus ensuring the delivery quality of concrete. Come to our website for more relevant content http://www.sdzkjf.cn Ask!