对于水泥自上料搅拌车的朋友来说，下雨天心里应该会拒绝吧。下雨天不仅会降低驾驶安全，下雨的话工地会停止，司机的朋友们也只能在家等待工作，但也有例外。下雨天工作的话，需要注意那些问题呢？

For the friends of cement self loading mixer truck, they should refuse in the heart on rainy days. Rainy days will not only reduce driving safety, but also stop the construction site if it rains, and the drivers' friends can only wait at home for work, but there are also exceptions. What problems do you need to pay attention to when working on rainy days?

一、提前准备。

1、 Prepare in advance.

雨季工作困难时，重要的是预防工作，出车前应该详细了解天气状况。天气预报可能是洞，但需要做好心理准备。出车前仔细检查车辆发动机、底盘、轮胎、制动器、雨刷、空调、液压系统、搅拌装置等，排除故障，保证正常工作。

When it is difficult to work in rainy season, it is important to prevent work, and the weather conditions should be understood in detail the day before driving. The weather forecast may be a hole, but you need to be prepared. Carefully check the engine, chassis, tires, brakes, wipers, air conditioner, hydraulic system, mixing device, etc. of the vehicle before driving out to eliminate faults and ensure normal operation.

驾驶室也要经常准备遮雨装备，以免不时之需。同时，要保证水箱里有足够的水，带减水剂和车一起调和混凝土。在启动车辆之前，为了防止车辆启动后减速机和液压系统的压力过大而损坏搅拌车的罐体处于停止位置。

The cab should always be equipped with rain protection equipment to avoid unexpected needs. At the same time, it is necessary to ensure that there is enough water in the water tank, and the concrete shall be mixed with the water reducer. Before starting the vehicle, in order to prevent excessive pressure of the reducer and hydraulic system after starting the vehicle from damaging the tank of the mixer truck, the tank is at the stop position.

二、雨天开车要小心。

2、 Drive carefully on rainy days.

不幸的是，运输途中遇到雨雪天气，千万不要着急。不要因为害怕影响混凝土的质量而高速前进。首先，减速缓慢，确保自己的人身安全，确认刹车是否正常工作。当汽车行驶到潮湿的路面时，车轮的抓地力会随着速度的增加而急剧减小，所以应该采用点刹车的方式，使车辆不失控地降低行驶速度。

Unfortunately, in case of rain and snow during transportation, please do not worry. Do not advance at high speed for fear of affecting the quality of concrete. First, slow down, ensure your personal safety and confirm whether the brake works normally. When the vehicle runs on a wet road, the grip of the wheels will decrease sharply with the increase of the speed. Therefore, the method of spot braking should be adopted to make the vehicle reduce the running speed without losing control.

对于没有硬化的道路，好不要突然前进，否则可能会陷入泥泞。遇到积水路面时，应在观察后确认安全后再通行，对于不熟悉的路程，应沿前车路线行驶。

For the road without hardening, do not advance suddenly, or you may get stuck in mud. When encountering waterlogged road surface, it is necessary to observe and confirm the safety before driving. For unfamiliar roads, it is necessary to drive along the route in front of the vehicle.

根据情况，及时打开前灯、雾灯和双闪灯，警告过去的车辆，增加安全系数。转弯前降低行驶速度，减慢罐子的转速，尽量大转弯，搅拌车的高，容易翻转。出现积水路面时，轻轻踩下制动踏板，立即蒸发制动片和制动盘的水分，恢复制动效果。如果雨较大的话，为了保证行驶的安全，好选择有遮挡的地方避雨，确保混凝土的质量。

According to the situation, turn on the headlights, fog lights and double flashing lights in time to warn the passing vehicles and increase the safety factor. Before turning, reduce the driving speed, slow down the rotation speed of the tank, and make a big turn as much as possible. The center of gravity of the mixer truck is high and it is easy to overturn. In case of ponding on the road, gently step on the brake pedal to immediately evaporate the water of the brake pad and the brake disc to restore the braking effect. In case of heavy rain, in order to ensure driving safety, it is better to choose a sheltered place to avoid rain and ensure the quality of concrete.

到达目的地时也不能疏忽。雨后工地湿润，确保安全后前进，注意工地钢筋、石头等垃圾对轮胎的影响。放入材料的时候好自己盯着。休息也不错。如果有什么错误，就得赔偿损失。拆卸后，请仔细清洗搅拌罐，以免混凝土粘在罐体上，凝固后无法清除。

You can't be negligent when you arrive at your destination. The construction site is wet after the rain, and advance after safety is ensured. Pay attention to the impact of garbage such as reinforcement and stones on the tires. Keep your eyes on the materials when you put them in. The rest was good. If there is any mistake, I must compensate for the loss. After disassembly, please clean the mixing tank carefully to avoid the concrete sticking to the tank and cannot be removed after solidification.

此外下雨停止后，司机们应认真检查容易受到雨水影响的部分，如仪表、操纵杆、万向轴、液压系统等。如果发现任何异常，应及时维护，以确保下一辆搅拌车的正常和安全运行。更多注意事项就来我们网站http://www.sdzkjf.cn咨询吧。

In addition, after the rain stops, drivers should carefully check the parts that are easily affected by the rain, such as instruments, control rods, cardan shafts, hydraulic systems, etc. If any abnormality is found, it shall be maintained in time to ensure the normal and safe operation of the next mixer truck. For more information, please visit our website http://www.sdzkjf.cn Consult.