1、 As a concrete mixer, the concrete mixing tank should be maintained first, and the new concrete mixer should be used to fasten the tank support and the chassis frame of the vehicle in real time. After each concrete transportation and into the cleaning tank, it is necessary to know that the concrete is easy to bond with steel.

二、出料的匀称性问题是水泥自动搅拌车机能的一个重要指标之一,它直接影响着施工质量。在运送混凝土时,搅拌筒转速应节制在2~5r/min,在运送间隔较长可能混凝土的塌落度较大时,出料前应先将搅拌筒快速动弹5~10圈,使内里的混凝土能充实搅拌,这样出料的匀称性就会大大提高。若途中混凝失水,到工地应加水调解,并充实搅拌,虽然这种环境应只管制止,但是这样会使混凝土的质量得不到担保。有的用户在利用时不留意节制在运输历程中的转速,过快会增大燃油的耗损,过小则会造成混凝土离析。因此应严格凭据要求来节制搅拌筒的转速,以提高混凝土运送质量。

2、 The uniformity of discharging is one of the important indexes of the function of concrete mixer truck, which directly affects the construction quality. When transporting concrete, the rotation speed of mixing drum should be controlled at 2 ~ 5R / min. if the transportation interval is long and the slump of concrete is large, the mixing drum should be moved 5 ~ 10 times before discharging, so that the concrete inside can be fully mixed, so that the uniformity of discharge will be greatly improved. If the concrete loses water on the way, water should be added to the construction site for mediation and full mixing. Although this kind of environment should only be stopped, the quality of concrete will not be guaranteed. Some users do not pay attention to control the speed in the transportation process, too fast will increase the fuel consumption, too small will cause concrete segregation. Therefore, the rotation speed of mixing drum should be controlled strictly according to the requirements, so as to improve the quality of concrete transportation.

三、凝土限量不能高出罐体的大方量,因为混凝土强度品级差别它的密度也差别,高强度混凝土一般密度也大,同样的体积,装多了对车倒霉。输送混凝土的容量、质量及坍落度应切合车辆利用说明书中的规定,实时加注润滑油。

3、 The maximum limit of concrete can not be higher than the maximum volume of the tank, because the concrete strength grade is different, its density is also different, high strength concrete is generally of high density, the same volume, too much loading is bad for cars. The capacity, quality and slump of concrete to be transported shall be in accordance with the provisions in the vehicle operation manual, and lubricating oil shall be added in real time.

四、露天停放过的水泥自动搅拌车,装料前应先将搅拌筒以出料偏向旋转,把水泥罐内的积水放掉,确保运送混凝土的质量。

4、 For the concrete mixer truck which has been parked in the open air, the mixing drum should be rotated to discharge the water in the cement tank before loading, so as to ensure the quality of concrete transported.

五、公路上行驶时,卸料溜槽降至低处并转至与车身垂直部位,用锁紧装置把卸料溜槽锁紧在机架上,防备由于不牢靠而摇动,造成伤人变乱和影响其它车辆运行。假如阶梯状况欠好,会对罐车的罐轴有损伤。

5、 When driving on the road, the unloading chute is lowered to the lowest position and turned to the vertical part of the vehicle body. The unloading chute is locked on the frame with the locking device to prevent it from shaking due to instability, causing injury and disturbance and affecting the operation of other vehicles. If the ladder condition is not good, the tank shaft of the tank car will be damaged.

六、卸料前,假如发现水分蒸发、坍落度偏低等不能满。用户要求时,可适当向搅拌筒内加水,然后按进料偏向以6~10r/min速度旋转30转后再卸料。

6、 Before unloading, if the water evaporation and slump are found to be low, it can not be full. When required by the user, water can be added into the mixing drum properly, and then the material can be discharged after 30 rotations at the speed of 6 ~ 10R / min according to the feeding deviation.

七、水泥自动搅拌车在运送混凝土的历程中搅拌筒不得遏制动弹,以免混凝土发生离析现象。

7、 In the process of transporting concrete by concrete mixer truck, the mixing drum shall not contain moving motion, so as to avoid concrete segregation.